城市污水厂剩余污泥对水中F-的吸附性能研究

利用城市污水处理厂的剩余污泥对水中F-进行吸附处理,通过污泥投加量、F-初始质量浓度、时间、pH等反应条件的研究,探讨除氟效果和影响因素。结果表明,室温下,污泥对F-的吸附在60 min后达到平衡;20 g/L的污泥投加量对10 mg/L含氟水的F-去除率可达83.1%;污泥可在3~10的较大pH范围内保持稳定的除氟效果。准二级动力学模型很好地拟合了污泥对F-的吸附行为,Langmuir和Freundlich模型均符合污泥对F-的吸附特性,热力学参数的计算表明该吸附过程是自发的放热反应。     

短程反硝化耦合厌氧氨氧化工艺及其应用前景研究进展

短程反硝化以其碳源消耗量、废污泥产量、温室气体排量极低及无需曝气等优势，被认为是最具研究潜势的厌氧氨氧化底物供给技术，成为近年来研究热点。本文首先介绍了短程反硝化工艺原理；其次从污泥源、反应时间、碳源类型、碳源量及pH等5个方面总结了影响短程反硝化工艺启动因素；随后综述了短程反硝化耦合厌氧氨氧化工艺的重要研究进展，同时指出了耦合工艺实验研究与工程应用的不足，并提出了解决实验与工程应用缺陷的方案；最后展望了耦合工艺处理城市污水和工业硝酸盐废水的可行性及应用前景，认为全面分析工业硝酸盐废水化学组分与基于分子生物学水平的宏基因组学测序、元转录组学技术是未来耦合工艺同步处理城市污水和工业硝酸盐废水的研究重点。     

Study on migration characteristics of heavy metals during oil sludge incineration

Experimental and simulation studies on the migration characteristics of heavy metals during the incineration of OS were conducted with a tube furnace reactor and thermodynamic equilibrium calculation software FactSage, respectively. The results showed that when the incineration temperature increased from 800°C to 1100°C, the release rates of heavy metals such as Cr, Pb, Cu, Zn and Ni increased gradually and reached the maximum at 1000°C. When the excess air ratio increased from 1.0 to 1.4, the release rates of heavy metals such as Cr, Pb, Cu, Zn and Ni first decreased and then became steady. The content of gaseous hydroxide of Cr and gaseous chlorides of Pb and Cu increased while the chemical forms of Zn and Ni did not change obviously with the increase of combustion temperature or excess air ratio.     

Anaerobic co-digestion of food waste and FOG with sewage sludge – realising its potential in Ireland

The severe environmental pollution in many countries is caused by indiscriminate discharge of large quantities of food waste (FW), fat oil and grease (FOG) and sewage sludge (SS) to the environment. There are many possible treatment routes, but anaerobic digestion (AD) is now well accepted for treating several kinds of organic wastes. But AD of FW alone presents some operational challenges because of substrates and variability. Anaerobic co-digestion of two or more substrates is better than single substrate digestion. This can use a plant’s unused capacity, in line with the trend to renewable energy. Co-digestion technology, although well established in many European countries, is still in its infancy in Ireland. There are problems with different regulatory arrangements. They should be resolved. The paper reviews anaerobic co-digestion technology is reviewed, with special focus on possible application in Ireland.     

Hydrothermal Carbonization of Sewage Sludge: Analysis of Process Severity and Solid Content

Hydrothermal carbonization of sewage sludge was carried out with the aim to evaluate the influence of process severity and initial solid content. Response surface methodology was applied to model yield and C yield responses. Enhanced dewaterability performance was recorded under mild processing conditions. The treatment promoted concentration and immobilization of Pb, Cd, Ni, Zn, and Cu. Variation of the solid content showed a stronger influence than severity on average yield and C yield. Higher heating values (HHVs) and energy retention efficiencies (EREs) of hydrochars obtained at the lowest solid content displayed the lowest values. Hence, the energy requirements of a first dewatering step should be compared with the related improvement in terms of HHV and ERE when sludge is used as feedstock.     

填料生物转盘对农村家庭生活污水的处理

根据目前我国农村生活污水处理的现状以及农村家庭污水水量、水质的特点,提出了一种家庭生活污水处理装置-填料生物转盘。该装置采用生物膜法工艺,结合生物转盘与生物滤池工艺的特点,运用设备一体化的设计理念,设计了一种运行管理简单、结构紧凑的一体化装置。通过实际运行考察了装置用于农村家庭生活污水处理的挂膜启动情况,以及污染物的去除效果。结果表明:填料生物转盘生物膜的驯化培养需要20天的时间,稳定运行期间对COD、NH4+-N、TN、TP的平均去除率分别稳定在75%、85%、65%和75%以上,出水COD、NH4+-N、TN优于城镇污水处理厂污染物排放标准(GB 18918-2002)一级A标准,出水TP达到一级B标准。装置运行管理操作简单,不需要专业技术人员,适合农村家庭污水的处理。     

气化灰基腻子粉的制备与性能研究

为实现气化灰综合利用和降低腻子粉制备成本，研究了利用气化灰替代水泥制备腻子粉的技术可行性。以气化灰和 42.5水泥为主要原料，配以少量的羟丙基甲基纤维素和可分散性乳胶粉，制备气化灰基腻子粉，实验考察原料配方变化对腻子粉的性能影响。研究结果表明：利用气化灰替代水泥制品制备腻子粉具有可行性。其中，气化灰替代 50%水泥时，腻子粉的粘结强度为 0.82 Mpa，各项性能均优于建筑外墙用腻子粉标准 JG/T 157—2009要求。在相同条件下，气化灰替代不超过 70%的水泥时，腻子粉的粘结强度及其他指标均满足建筑外墙用腻子粉标准 JG/T 157—2009要求。     

生物质电厂废弃物草木灰成分分析及成形

生物质热电厂焚烧废弃物的主要成分是草木灰，其产生量大、密度小。大量草木灰不经处理会造成环境污染问题。本文首先分析草木灰的化学成分，确定草木灰的肥料特征，通过添加NH₄H₂PO₄使草木灰的pH达到国家复合肥的相关标准。选用聚天冬氨酸（30%水溶液）作为复合肥的黏结剂，应用于草木灰复合肥的成形造粒，以增加其抗压强度和肥效。研究不同烘干时间、烘干温度、聚天冬氨酸添加量对草木灰复合肥抗压强度的影响规律，通过分析植物的形态及生理指标，进而研究草木灰复合肥的肥效。结果表明：最佳烘干条件为10h、140℃，聚天冬氨酸对草木灰的抗压强度有明显的增强作用，并且草木灰与聚天冬氨酸的复配比为6g∶1mL时肥效最好。此方法解决了元素循环中断、草木灰环境污染，在运输过程中草木灰复合肥易碎，纯草木灰肥效低等问题。     

窑灰作脱硫剂的水泥窑湿法脱硫系统优化

针对水泥窑生产工艺中生料磨启停工序引起的烟气温度、二氧化硫浓度对湿法脱硫系统的影响以及杂质对湿法脱硫系统设备和浆液储罐的影响,提出了优化设计方法和运行措施,以便达到较好的烟气脱硫效果。实践表明,该工艺综合循环利用窑灰作脱硫剂,不仅可将烟气中二氧化硫能够达标排放,而且脱硫副产物石膏可作为水泥缓凝剂添加料,有较好的工程应用价值。